Industrial Oil Fired Steam Boilers Case

Industrial Oil Fired Steam Boilers Case

Natural gas boiler is a kind of thermal energy conversion equipment, which uses natural gas, liquefied gas, city gas and other gas fuels as fuel to burn the heat released from the furnace, heat the water in the pot, and make it vaporize into steam. Water in a pot (drum) is constantly heated by the burning of gas fuel in the furnace to heat up the temperature and produce pressurized steam. Because the boiling point of water increases with the increase of pressure, the pot is sealed, and the expansion of steam in the boiler is restricted to produce pressure to form a thermal force. Strictly speaking, the steam of a boiler is heated to saturated water and vaporized in the drum at constant pressure. It is widely used as an energy source. Natural gas boiler heating In order to protect indoor warmth and human health, so when choosing natural gas boilers, safety issues are very important, and quality issues can not be ignored, only with good quality, in the use of more assured. Some services can also be done better, the choice of heating is customer satisfaction. Understanding natural gas boilers is certainly a need to know the sales situation of the products, if the natural gas boiler reputation is good, it is still very good in comprehensive aspects, worthy of consumer choice, the conversion of performance and thermal energy can also be consulted. There will be no problems when used like this, and there will be no need to worry about electricity during installation The pressure is not enough. Natural gas boiler shut-down method: after stopping the powder feeder, blow the primary duct for 5 minutes before stopping the oil gun. Oil guns should be blown one at a time, not multiple at the same time. After blowing the gun, ventilate the furnace of natural gas boiler for 5 minutes for 8 minutes, and the air volume is not less than 20% of the rated load. To remove combustible material from the furnace. According to the fuel, natural gas boiler can be divided into natural gas industrial fired steam boilers case, city gas steam boiler, coke oven gas steam boiler, liquefied petroleum gas steam boiler, etc. According to the structure form, it can be divided into vertical steam boiler and horizontal steam boiler. Natural gas boiler is shell type Full wet backflow three-way pyrotechnic tube structure, flame combustion in large combustion chamber micro positive pressure combustion, complete extension, low combustion heat load, high combustion heat efficiency, effectively reduce the exhaust temperature, energy saving and consumption reduction, use more economical, The heat absorption strength of the boiler is improved by adopting the structure of corrugated furnace tank and threaded smoke pipe, and the heat exchange surface is expanded to meet the need of heat expansion. It is scientific, reasonable and durable.

The fuel can be natural gas boiler into gas-fired, city gas boiler, boiler coke oven gas, liquefied petroleum gas boilers and boiler; functions can be divided in accordance with KS-Q water natural gas boiler, CLHS / CWNS natural gas hot water boiler (including natural gas heating boilers and gas boilers bath), LHS / WNS natural gas and industrial fired steam boilers case; can be configured in accordance with natural gas boiler is divided into vertical and horizontal natural gas boiler; flue gas flow can be divided according to a single backhaul gas three-pass boilers and natural gas boilers. Fuel oil-fired boiler is the difference between a fuel (such as diesel, oil, kerosene, etc.), natural gas boiler fuel is natural gas (such as natural gas, city gas, biogas as well as liquefied petroleum gas, etc.), depending on what fuel boiler combustion devices called burner, natural gas burner configuration called boiler natural gas boiler, oil boiler burner configuration called oil-fired boiler, oil-fired boiler and the difference between natural gas boiler that what fuel burners.

Battle blue horn sounded, emissions of sulfur, nitrogen and oxygen compounds gradually strict national requirements. To improve the quality of the environment, but also the people a blue sky, in all industries around the environmentally friendly product revolution, Hainan Sinochem Pharmaceutical companies are no exception. By the company investigation and comparison of boiler products, in March 2017 signed a six-ton ​​steam-cleaning integrated condensing gas boiler and steam fast boiler. Tested and post feedback, the boiler equipment installation qualification, operating normally, and successfully passed the inspection by local quality inspection departments of the boiler.

Electric industrial fired steam boilers case steam boiler characteristics 1, security: 1 leakage protection: When the boiler leak, promptly cut off the power supply through leakage circuit breakers, to ensure personal safety. (2) Water protection: When the boiler water, promptly cut off the control circuit of the heating tube, heating the tube to prevent damage to dry. Meanwhile, the controller sends water alarm signal. Ground fault protection: charging the boiler housing, the leakage current through the ground line to ground is introduced to ensure personal safety. In general, to maintain good protective grounding wire connected to the metal, the depth of the underground pipe angle as grounding, the grounding resistance should not exceed 4. Steam overpressure protection: When the boiler steam pressure exceeds a set limit pressure relief valve start and release the steam to reduce the pressure. (5) The overcurrent protection: When the boiler overload (high voltage), earth leakage circuit breaker is automatically disconnected. Power Protection: With advanced electronic circuit detects over-voltage fault condition, voltage, disconnection, to provide reliable power protection. 2, to facilitate: a power supply after the introduction of the electrical control box, a key press operation, the boiler will enter (or leave) the automatic running. (2) reducing the water boiler, the control system will automatically replenish the water tank to the boiler through a replenishment pump. 3. rationality: In order to reasonably effectively utilize electric energy, in particular the heating power divided into several parts, automatic cycle input by the controller (cutting) the heating power according to a user's actual needs, just close leakage breaker ( or press the corresponding switch) can. Biomass boiler is a kind of boiler to biomass energy as a boiler fuel called biomass boilers, steam boilers into biomass, biomass hot water boiler, biomass stove, biomass thermal oil heaters, vertical raw biomass boilers, biomass boilers and other horizontal. Heating pipe segment switching cycle reduces the impact on the grid of the boiler in operation. 4. Reliability: a bottom of the boiler furnace using arc welding, manual welding surface of the furnace cover, and the furnace strict X-ray detection. (2) boiler steel production in strict accordance with the standard selection. (3) boiler accessories selected domestic and international high-quality products, and the boilers were tested in order to ensure long-term normal operation of the boiler. Oil (gas) steam boiler steam boiler 1. Gas burner provided by the well-known manufacturers in the world. According to a command of the controller, the automatic combustion stop, the program controller having a plurality of independent security protection, security and stability performance, low maintenance. 2, the controller automatically advanced steam boilers, Chinese LCD display, man-machine interface, the user simply easily set, according to user requirements the boiler can start and stop, load adjustment, automatic water supply automatic operation. The boiler fully functional, complete protection, simple operation, safe and reliable, has a self-diagnostic function. Once the boiler operation anomalies occur, it will automatically interrupt burn, concurrent sound and light alarm. 3. Zhuoyi Li steam boiler burner shutdown mode, two circuit configuration, fuel combustion, boiler stable; flue insert spoiler, smoke slow speed, increasing the heat transfer, high thermal efficiency, reduced user cost. 4. The steam boiler is a horizontal shell-and refluxed for three full moisture pyrotechnic reflux pipe structure, not only improves the strength of the heat absorption of the boiler, but also meet the needs of the expanded heat transfer surface, a scientific and rational. There are heating and hot water boiler bath for two purposes. Hot water boiler by circulating hot water circulation pump hot water holding tank, the tank hot water heating cycle can be achieved bath object; hot water boiler by circulating hot water circulation pump heating conduit, through the heat sink (radiator) people can achieve heating requirements; hot water boiler and hot water circulating pump with heat exchanger can be achieved bathing and heating dual function. Durable.

Free Chat

About Us

Contact Us