Types Of Low Pressure Boilers

Types Of Low Pressure Boilers

Why should I bake the types of low pressure boilers before I burn it? This is because the whole boiler can heat up slowly through the operation of drying, so as to avoid excessive temperature difference stress in the bottom of the furnace, so that the furnace body will be damaged or cause the furnace body to burst in order to avoid the excessive temperature difference stress caused by the rapid heating up of the bottom of the furnace. Therefore, in order to avoid these problems, oven operation should be carried out before burning the boiler, at the same time, the boiler can also play a protective role.

Main steam valve should be installed near the outlet of the drum or header of the superheater. Main steam valve vertical shell types of low pressure boilers may be installed in the boiler room to facilitate local operations. On each steam boilers and steam pipes connected to main pipe, two gate valves shall be installed, should be fitted with a valve and open to the atmosphere between the trap valve, the inner diameter> 18mm.

How flue gas condensing types of low pressure boilers condensate Henan excessive treatment? When Henan gas condensing boiler furnace particularly in cold start operation, the heating surface and the rear of the boiler smoke box at the rear often flue gas condensation water generated, so that the boiler stokers mistaken leaking. Henan condensed water generating smoke gas condensing boilers are mainly two reasons: 1 flue gas to condense water vapor at a temperature below the dew point; 2 Henan high gas condensing boiler thermal efficiency, low exhaust gas temperature... Henan gas condensing boiler flue gas temperature slightly higher than the dew point temperature of the flue gas can be economic security operation at rated load, but Henan gas condensing boiler in the case of low load long-running, flue gas temperature is lower than the dew point temperature of flue gas, in this case the condensed water from flowing out of the tail heating surface of the boiler, the boiler is discharged from the smoke box. A German boiler remind you: hot water boiler condensate produced during operation should be promptly eliminated from the boiler, because if excessive accumulation of condensed water will affect the normal operation of Henan gas condensing boiler can cause serious after the smoke box door and smoke box flange connections leaking. Specific measures include: 1 Henan gas condensing boiler condensate outlet is provided in the rear box to smoke condensate water can be discharged, the outlet valve is disposed generally not taken over, seal should be provided to prevent the flue gas from the tube Yi out. 2. smoke box provided to take over the outlet flue gas condensing boiler Henan discharging into the chimney smoke box, because heat is still continued cooling chimney, flue gas water vapor condenses continues in the chimney wall, in the form of small droplets flow down the chimney wall, and therefore should be set to take over the smoke box outlet, the condensed water can be discharged into the trench or any drainage system. Henan flue gas condensing boiler condensate phenomenon should cause too much concern, although the condensed water can not be avoided, but too much condensed water, bound to have a safe operation of the gas condensing boiler Henan have an impact.

AMD Power were to buy 10 tons of steam and one 4 tons of steam condensing steam types of low pressure boilers fuel gas from the company for cell processing company production and construction. From the analysis of the demand to the boiler factory, by the company solely responsible for AMD Power fully demonstrated the company's confidence in me, the smooth progress of bilateral cooperation.

Free Chat

About Us

Contact Us