Oil-fired boilers are more convenient than traditional boilers in environmental protection, but their fire protection system is indispensable because of the particularity of oil, and its fire protection is mainly as follows:
1. There should be a reliable anti-static and safe grounding device in oil tank area and discharge pipeline, and the grounding resistance value (less than 0.5 ohms) should be tested regularly. 2. It is forbidden to store combustible materials in oil area and temporary buildings which are easy to catch fire should be dismantled in time. 3, it is prohibited to do welding work in the running or off-standby state of the oil pipeline. When welding must be carried out on an oil pipeline, before welding, the oil pipe that needs to be welded must be disconnected from the oil system in operation or standstill status (such as removing the welded oil pipeline or home plug) and then flushing the pipeline, Ensure that its interior is oil-free, oil and gas to prevent welding operations are oil and gas deflagration . 4. When open fire operation in oil area, must handle fire work ticket, and should be reliable safety measures. 5. We must strictly implement the oil zone management system. The foam fire fighting system and fire extinguishing equipment of the oil system of the oil fired boiler must be inspected and tested regularly according to the regulations. 7. Hose for fuel system should be periodically checked for replacement. To prevent fuel leakage due to hose aging. If oil leakage is found in insulation material during maintenance, oil leakage point should be eliminated and heat preservation material should be replaced. 9. Monitor the oil temperature of the oil tank. If the oil temperature exceeds 50 ℃, the spray water should be put into the oil tank. That's all the fuel. Boiler fire code, I hope everyone for their own safety please strictly abide by.(119) Preparedness of fuel-fired boilers before ignition
Hot water boiler installation instructions for installation and use 7mw fired hot water boiler in russia installation and commissioning of boiler pressure hot water boiler in order after the first, depending on the size of the boiler, cast in at 200mm above the ground. A boiler installation should be dry and ventilated room, ease of maintenance, there should be four weeks fuel, the boiler chimney installation shall comply with the requirements; the diameter of the chimney should be small, so as not to increase the exhaust resistance and impact performance of the burner. Stack height not less than 3 m, 1 m higher than the cap housing, the top of a rain hat. Henan fast boiler piping system configuration according to the new construction needs may be. Replenishing the tank should have sufficient capacity to control the makeup tank and devices (e.g., float) water level. Diameter of the exhaust pipe can not be arbitrarily reduced in order to avoid vapor pressure furnace. Outfall height of not less than 3 meters, may be introduced into the sewage outlet, sewage outfall any part of the valve shall be provided to ensure that it is connected to the atmosphere. Pipeline system pumps, valves and the like. A reasonable match. The boiler installation, the burner match check, whether the fuel is required to use, the oil (gas) is smooth passage correctly, power is correct, whether the grounding wire connected, if appropriate with the flue conduit and open the drain. Before firing tests, to check whether there is water inside the oven. Adjusting the temperature control of the temperature required. When the temperature reached, the burner will automatically stop. When the temperature is below the set temperature, the burner starts automatically. Check the burner is normal, if not burning, adjustable pump pressure or gas pressure, and flow valves, to be properly secured. Ensure safe operation. Zidongkongzhi means (indoor controller) function and application unit 1 Zidongkongzhi 1:
Hot water boiler fuel oil 7mw fired hot water boiler in russias brief automatic control system has a high-tech, with a number of security devices, water protection, overpressure protection, flame protection, abnormal pressure protection, over-temperature flue protection; structure using tech, having a body holding a small, compact and easy to install, easy to operate, automatically adjust the pressure of the fuel to the atomizing, a slight positive pressure of the combustion so that fuel combustion and then more fully, and to reduce the loss of the fuel gas discharge, modern industrial steam is the most convenient and most energy-efficient, environmentally friendly standard products. The need for comprehensive maintenance of the gas hot water boiler gas hot water boiler for normal use, to do regular inspection and maintenance, however, has been used for a three-year-old boiler, we must conduct a more comprehensive repair work. 1, carrying out comprehensive maintenance check, the first thing to be clear inside the boiler ditch and sludge, after using water to rinse these ditches and sludge. 2, the boiler for burning site, there will be a large amount of soot and fouling, but also in such substances when overhaul, the cleanup process. 3, because the gas hot water boiler is used in metal processing and production, but also a lot of contact with water or steam, it is inevitable there will be erosion situation, when the boiler overhaul, to the corrosion phenomena boiler maintenance treatment Finally, we need to do to level the boiler fire boiler use paint protection to prevent future corrosion conditions.
Food is food industry is human life industry, but also an ancient and eternal evergreen industry. Industrial steam boiler as an integral part of the chain, is mainly used for processing of distillation, extraction, sterilizing, drying, curing and other processes. Anqing City, Anhui Province is located in the Want Want Foods Co., Ltd. mainly engaged in all kinds of puffed food processing and manufacturing and sale of steam boiler steam delivered directly or indirectly in contact with food, thus requiring the steam quality is very high. Due to expanding production needs, Want Want Foods in urgent need of a boiler plant to provide high-quality steam. After a comprehensive understanding of the boiler industry, determined to cooperate with the fast boiler. Want fast square perennial cooperation with the country's food company, it has considerable experience of cooperation. By understanding the needs of the Want Want food production, providing a whole 10 tons of steam condensing gas steam boiler (WNS10-1.25-Y.Q).Free Chat
Copyright © 2020.Company name All rights reserved.