Steam boiler fuel gas composition changes so the General Assembly cause flameout: fuel gas 150psi steam boilers in ecuador pressure off the fire caused by a sudden rise, the solenoid valve malfunction the gas supply interruption, the gas composition has changed so much moisture content is too high and so on. Blower, fan failure, the load is too low furnace pressure is too large excessive leakage and other excessive wind, so that the furnace temperature is too low can also cause steam boiler fuel flame. Causes fuel steam boiler flameout are: oil pump failure, the oil surface is exposed inhalation tube, clogging of the oil filter or oil supply pipe, a solenoid valve malfunction or misoperation caused by oil running intermittently. During transport the fuel with steam by heating water; inappropriate position inhalation tube with the pumping of water; improper contaminated oil floating on the water; poor dewatering tank drain plug such that the fuel with water.
If the configuration boiler fuel gas or dual fuel burners, then the boiler is oil or gas boiler. Fuel gas-fired boiler is a more general concept, fuel gas-fired boiler is divided into water boilers, hot water boilers, 150psi steam boilers in ecuadors and thermal oil boiler, according to their own use to select a different fuel gas-fired boiler time of purchase.
Steam boiler water treatment equipment What is the role of the boiler itself? Core Tip: boiler water treatment of new fuel gas steam and basic purpose. Well boiler water treatment is an important element to ensure the safe and economic operation of the boiler. Due to the high combustion temperature of the oil, gas. And most of the oil, gas boilers (especially imports of fuel gas-fired boiler) small size, compact structure, higher requirements for water quality, water treatment, if done well, it will cause boiler fouling, corrosion, not only a waste of fuel and easy caused by blocked pipes, burst pipes and other accidents, causing serious boiler will be scrapped biggest economic losses. Therefore, fuel oil and natural gas boilers have to do a good job of the basics of boiler water boiler water treatment.
Coal-fired boiler not only seriously polluted air, which produces a large amount of waste water sludge can also cause serious water pollution and soil contamination. To protect the city of Tongren green water blue sky, since 2014, led by the city of Tongren City, Guizhou Bureau of Quality Supervision, of 10 steam tons / hour within built-up areas and Tongren City High-tech Zone, Economic Development Zone, Tai Lung range and below, in Guizhou tobacco industry limited liability company Tongren cigarette factory, Tongren City, drug rehabilitation centers, Tongren Wantong construction and development Co., Ltd. and other 36 enterprises of coal-fired boilers to carry out an intensive diagnostic investigation. One by one on the ground to verify the registration, and the companies signed an undertaking to ban coal-fired boilers eliminated; to effectively reduce the burden on enterprises, according to the spirit of the document, to take the initiative within the time limit or eliminate the use of coal-fired boiler unit to switch to clean energy, the after review and acceptance Municipal Environmental Protection Bureau, according to the amount of coal-fired boilers hour evaporation reward, award criteria tons of steam per 30,000 yuan subsidy.
Up to now, the city of Tongren out of 36 coal-fired boiler units, a total of 43.051 tons of steam, an award subsidies 1,291,530 yuan, so far, the city of Tongren jurisdictions total phase-out of all coal-fired boilers, and lay a good foundation for the creation of ecological civilization demonstration area.Free Chat
Copyright © 2020.Company name All rights reserved.