Use electric heavy fuel fired steam boiler electric steam boilers for cooking food processing, printing and dyeing, pharmaceutical, clothing iron, road maintenance, to provide production to provide steam sterilization with steam, medical institutions, other enterprises and to provide heated water tank, hotels, bathrooms by domestic hot water. Washing Ironing industry: dry-cleaning machine, dryer, washing machine, dryer, ironing machine, iron, and other equipment for use. Food Machinery Industry: supporting tofu machine, steam boxes, cans sterilization, packaging machines, coating equipment, sealing machines, and other devices using Bio-chemical industry: a fermentation tank, reactor, sandwich pot, mixer, emulsifier and other equipment supporting the use of other industries :( oil, automobile) steam cleaning industry (hotels, dormitories, schools, mixing station) hot water supply, (bridges, railways) concrete curing, (casual beauty club) sauna, hot swap equipment.
Operation of a gas boiler gas boiler in Henan related to maintenance, the ignition operation, fire, shutdown and some other operational measures: First, the gas boiler maintenance Henan, operating procedures should be required to carry out tests on the gas transmission main boiler protection devices, ensure that the main protection correct action. Second, the ignition process Henan gas boiler, fuel pressure, fuel temperature, steam pressure atomization, atomization steam temperature and other parameters must meet the requirements of operating procedures, good place to observe oil gun fire, fire detection return to normal, prohibit short-energize inspection signal forcibly put into the oil gun running. Single oil gun when the flow is greater than 0.65kg / s, exit the gun should be run immediately. Third, observe boiler ignition temperature rise rate of fire smoke significantly Pianman furnace flue gas temperature of the main steam temperature, steam pressure rises when the main, the case of smoke or boiler ignition temperature did not rise immediately to check the opinions of the oil gun, if No fire was found after the fuel into the furnace, emergency shutdown, re-ventilate the furnace purge Do not allow to run into the boiler ventilation oil gun. Fourth, note that starting mill to check whether the subject returns normally coals, coal mill outlet temperature of greater than 70 deg.] C line is allowed to increase the amount of coal (three grinding mill operation start of the fourth stage, the coal mill outlet line than 80 ℃ temperature allowed to increase the amount of coal, to prevent excessive vibration furnace). Full stop before the gun when the present discharge amount of coal is increased 5.0kg / s or more. 6.3.5 Operating Henan gas boiler, "furnace black", "lose the protection of the main fuel" must be put into operation as required operating procedures. In case of a fault protection device itself appears to be temporarily out of operation, to be approved by the competent manager or chief engineer before implementation. "Furnace black", "main fuel unprotected" means the period out of operation, priority monitoring attendant to furnace pressure, the oxygen, the main steam temperature, the main steam pressure and other parameters, and through the furnace of fire industrial television monitor, and if found hearth fire, emergency shutdown. Sixth, Henan gas boiler normal operation, the fuel system and oil spare gun good condition, found that boiler combustion instability immediately put oil combustion. Seven, after Henan gas boiler fire, into the oil gun is strictly prohibited without the operation of the boiler ventilation. Eight, gas boiler has confirmed the fire, when the MFT is not operating, emergency shutdown, and check that the two primary air fan, 4 mill, 16 oil gun has stopped running. Back nine, Henan gas boiler trip or normal shutdown to be purged immediately ventilate the furnace, the furnace unburnt coal dust and combustible gas pumped in a timely manner. And promptly shut down the boiler supply and return oil total gate manually to prevent leakage of fuel oil gun into the furnace. Ten, Henan gas boiler shutdown purge gun ban mill and pulverized coal into the furnace exhaust.
Steam boiler rules Henan fast boiler with small series to introduce the company's heavy fuel fired steam boiler operating procedures. First, the components of the steam boiler before oven cooking oven and check (a) and oven cooked boiler furnace must be checked in detail. Check the following items: 1, cold chain grate test more than 24 hours, cold test should meet the following requirements: (1) grate should be smooth turning chain wheel axle, found arched, two tension bolts can be tightened. (2) the active grate sprocket good occlusion. Minimum gap (3) on both sides of the active grate block with the side seal and the side seal angle not less than 6 mm. Distance (4) on both sides of both ends of the furnace grate platoon leader pin in the sprocket should be kept equal. If it is found at one end to the occurrence of side friction, long waist-hole may be a tap with a hammer, the end surfaces on both sides remains equal distance. (5) steam boiler grate rotated without jamming, deviation phenomenon, when the deviation found by the inspection hole into the rear grate tail, the tie bolt align the two bearings of the drum, deviation phenomenon can be eliminated. The boiler has ignition combustion, still need to transfer found Hearth n, just before two adjustable chain tensioning bolt shaft directly outside the furnace, but preceded align the front sprocket shaft and a gearbox connect the safety pin or bolt removed until after squaring shaft to a gearbox with a chain alignment pin or bolt after tightening, may otherwise result in misalignment with the sprocket shaft of a gearbox and mechanical damage. (B) Check broken grate furnace platoon leader pin is bent, if long waist hole in the furnace may be carried out at any time platoon leader pin alignment reload. (C) a chain grate does not allow foreign matters (such as bolts, nuts, nails and other iron) is present. (D) firing door open and flexible, easy to open and drop the shutter coal, coal gate left and right side of the grate surface distance equal to, the thickness of both sides of the seam to ensure equal furnace, as a method for reducing ranging from links available to make equal, coal shutter cover plate should cover tightly to prevent leakage into the coal, coal stuck shutter. (Five) of each grate windshield of smoke damper and damper adjustment inside the flue flexible switch. (Vi) blower, Fan, Java machine, commissioning normal water supply equipment. (Vii) manhole, hand hole is tight, attached parts fitted Ge are complete. (Viii) the furnace wall is normal, the flue is tight. (Ix) steam boiler pipes, water pipes, sewage road is complete. (J) all filled with lubricating oil in the bearing housing and oil cup. (Xi) All electrical equipment should be empty running test, inspection equipment, and other electrical lines is intact.
It is reported that Jinjiang City of Fujian Province will be fully started tackling air pollution prevention and control work, Market Authority as a proactive, Take Measures to promote coal-fired boiler renovation work.
Market Authority through three initiatives to further improve the environmental air treatment Jinjiang City, Jinjiang create "blue sky": strict criteria, the better the mark.
Actively cooperate with environmental protection, by letter and other relevant departments, coal-fired boilers do not meet environmental policy, shall not start to inform, Supervision, Inspection and registration certificate for the use of strict coal-fired boilers access gateway, departmental interaction, ensure its effectiveness.
Strengthen communication and coordination with environmental protection, by letter and other related departments and Towns, a solid job of remediation coal-fired boilers, out of work.
Combined area of gas supply, heating pipe network coverage, and vigorously promote the use of natural gas, electricity and other clean energy, and take the way government subsidies, coal-fired boiler to remove their push to ensure the prevention and control of atmospheric achieve results.
Step up publicity services in place. Organization of the market supervision area of propaganda out of coal-fired boilers policy of the increase, according to the sense of service, "a visit to promote a" do a good job guidance subsidies, removal and cancellation of work, and guide to remove their coal-fired boilers, and required to apply for removal of cancellation.Free Chat
Copyright © 2020.Company name All rights reserved.