12 Tons Gas Boiler Manufacturer

12 Tons Gas Boiler Manufacturer

Advancing the ignition point of coal, the temperature of the furnace to improve the ash carbon content decreased. Smoke swirling mix and strengthen the separation of coke particles in the flue gas, so that it falls on the fire bed and the new layer further fuel burn. Flue gas also strong swirl in the flue gas CO, H2, CH4 and other combustible combustion gases, thereby improving the thermal efficiency of the 12 tons boiler manufacturer is more than 4%. But also improve the boiler output to meet the needs of the production of steam, reducing environmental pollution, expanding the scope to adapt varieties of coal. 2. The air supply and reasonable regulation. In Grate, vibration stove, oven and forth, depending on the characteristics of the combustion process, reasonable air, to promote combustion furnace is very important. As the chain furnace, with grate the fuel is kept in motion, occur sequentially ignition, combustion, burn various stages. Along the longitudinal direction of the combustion grate stages, the partition, the amount of air required in the grate longitudinal direction is different. In the preheating zone of the head and the tail of burnout grate stage, small air requirement in the middle stage of combustion grate, the air amount required.

Problems coal 12 tons boiler manufacturer gas boiler gas coal problems are: 1, more coal ash, 2, unevenness of coal particles, 3, coal contains a large amount of impurities, 4, a lower heating value of coal, 5 when combustion is not easy to ignite fire, 6, coal moisture content uncertain. 7, does not burn coal, slag high carbon content. In general, use is preferably designed coal boiler design coal or coal close, in order to ensure stable combustion. In recent years due to the growing tension surrounding the coal supply, coal supply has become diversified, coal quality is very different than before coal, have a great impact on the stability of the boiler combustion and normal heating operation. Impact of coal combustion boiler stable for: calorific value of coal is coal reflects an important indicator of good or bad, when the low calorific value of coal to a certain value, will not only affect the incomplete combustion instability and can lead boiler flameout, the outlet temperature of the boiler is difficult to compliance, affecting the normal operation. Volatile combustion and can be deposited at lower temperatures, as the combustion heat, the temperature rapidly increased coke particles, provide an extremely favorable conditions for ignition and combustion, volatiles further increased coke deposition and internal voids and the external reaction area, will help improve the speed of burning coke. Thus, the greater the content of volatile, nonflammable, the less fixed carbon in the coal component, the easier coal burning ember, devolatilization of many voids, increases the surface area of ​​the reaction, the combustion reaction is accelerated. When the volatile content is reduced, pulverized coal ignition temperature significantly increased, the hot increases, difficult fire, ignition time required becomes longer, the combustion stability is reduced, shifting the center of the flame, furnace absorbed radiation heating surface reduce heat, increase the heat absorption of the convection heating surface, the rear exhaust temperature, exhaust loss increases.

"Coal to gas" birth 12 tons boiler manufacturer gas demand "from coal to gas" is one of the primary means to reduce air pollutant emissions. China's industrial coal-fired boilers, mostly without washing of coal, higher emission levels, the contribution of urban air pollution by up to 45% -65%. "Coal gas" will be replaced by coal-fired boiler, gas-fired, can significantly reduce emissions. In 2012, a number of ministries such as Ministry of Environmental Protection issued a document repeatedly requested the transformation of emissions large boiler products, such as "air pollution control in key areas" Twelfth Five-Year Plan "key projects" in the requirements, completed 2015 2841 clean energy transformation station over coal-fired boilers, which made it clear 465 coal-fired boilers replaced by a natural gas boiler. Since 2012, Beijing, Shanghai, Shijiazhuang, Lanzhou, and other places have been put forward more detailed policy requiring replace coal-fired boilers to natural gas boilers. Research shows that "coal to gas," the economy is weak, the policy is the main driving force. Due to higher gas prices, "to burn" after higher operating costs, such as coal-fired boiler and a full set of environmental protection equipment total annual cost of 661,900 yuan / (t / h), "coal to gas," the total cost of the annual 844,300 yuan / (t / h). Although a single coal-fired boilers to burn the economy is not strong, but mostly coal-fired boilers into a large gas-fired boiler feasible. Policy is the main driving force to promote the "coal to gas." It is understood that the gas boiler is facing 80 billion market demand, industrial boilers for the heavy head. According to "energy development" five "plan", "Boiler Air Pollutants Emission Standards", estimates derived gas boiler market space "Twelfth Five-Year" period about 800 million yuan, of which the industrial gas boilers for the heavy head, the market is 60 billion yuan; large gas power plant waste heat boiler to invest 150-180 billion yuan, natural gas distributed generation waste heat boiler to invest 50-60 billion yuan. According to "Natural gas development," second five "plan", 2015, China's natural gas supply of about 269.5 billion cubic meters. The demand side, China's gas power plant in 2015, distributed projects, industrial boilers totaling nearly 100 billion cubic meters of natural gas. By then sufficient air supply without worrying about gas shortage.

During the training, the participants visited the group to arrange a call center, research and development centers, production workshop, the participants said that through this training visit, the other fast Group's corporate culture, lean management, staff professionalism with a deeper understanding of each other soon Group Technology R & D investment, product quality control, after-sales service system construction with understanding. Participants said that the current visit and study, the other group soon have a new understanding, and trust each other more products faster, this is very good training visits, Hope Group to adhere to gone out of existence. Safety Training Week is running fast party group of service users yet another form, the Group will integrate a variety of services in the form of online and offline, adhere to convenient and efficient service concept, to provide users with the best quality service.

Free Chat

About Us

Contact Us